American-energy-systems CF-2300 Door User Manual download pdf

F:\AESBusinessSystems\AES Technical\Piece part instructions\CF-2300 Door Assembly.doc

CF-2300 Door Assemble

Used on O2 units

CF-175 (1) Door Handle

CF-177 (1) Door Latch

P7544 (2) Hex jam ½-20 jam

PP-38 (2) Hinge pin cap

CF-2300 (1) Door Assemble

PP-414-BLK 1 ½” Spring Handle

• Remove from packaging.

• Hold the opened door parallel to the stove, above hinge pins. Align the female portion of

the door hinge with the male portion of the stove hinge.

• Gently lower the door hinges over the stove hinge pins. Once the door hinges have been

set, the door can be closed to check proper fit.

• The door may require fine adjustment for proper seal. (See Figures 1 & 2) With the door

closed un-tighten the two hinge pin bolts approximately one turn. Raise or lower door as

required with the handle to the proper position. Check to ensure that the stove’s perimeter

door flange seats properly into the door gasket. Tighten the hinge bolts while holding the

door in place.

• The door seal must create an air-tight fit. To adjust the gasket tightness, rotate the door

latch (see Figure 3) one clockwise (loosen) revolution as necessary to adjust the gasket

seal and tightened by turning the handle one counterclockwise revolution.

• To test door gasket seal, place a slip of paper against the stove door frame and then latch

the door, tug paper gently. Continue this test around entire door frame. If gently tugging

on the paper does not dislodge it from the door, the seal is appropriate. If paper does

dislodge from the door, replace gasketing. Check the door seal with the paper test prior to

lighting stove.

• The door installation should now be complete. To remove the door, open completely and

lift the door from the stove hinges.

Figures 1&2: Adjustable Door Hinge Screws

Figure 3:

Door Handle Latch

F:\AESBusinessSystems\AES Technical\Piece part instructions\CF-2300 Door Assembly.doc CF-2300 Door Assemble Used on O2 units CF-175 (1) Door Handle

No comments

American-energy-systems CF-2300 Door User Manual