American Energy Systems T-40 AC Operations Instructions

AMERICAN ENERGY SYSTEMS, INC. OWNER’S INSTALLATION AND OPERATION MANUAL FOR PELLET FUEL BURNING HEATER Save these instructions MODEL

HORIZONTAL INSTALLATION EXHAUST VENT TERMINATION SHALL BE AS FOLLOWS: A MINIMUM OF 4 FEET/122Omm BELOW, BESIDE AND 1 FOOT ABOVE ANY DOOR OR WINDOW T

VERTICAL INSTALLATION GUIDELINES ON CONNECTING TO AN EXISTING FACTORY-BUILT CHIMNEY: 1. Inspect the chimney for the presence of creosote, soot or o

CONTROL PANEL/THERMOSTAT HOOK-UP WARNING: ALWAYS DISCONNECT POWER CORD DURING ANY ELECTRICAL OPERATION 1. Remove control panel from protective

OPTIONAL 12 VOLT BATTERY BACK-UP WARNING: ALWAYS DISCONNECT POWER CORD DURING ANY ELECTRICAL OPERATION Note: Never use an unsealed battery 1. Disc

OPERATING INSTRUCTIONS NOTE: Each time the stove is started, the firepot should be checked for debris and clear air holes. Some pellets will cause

OPERATION INSTRUCTIONS…continued PROPER FUEL This stove is designed and approved to burn pelletized wood fuel only. Do not use any other type of fue

CLEANING INSTRUCTIONS NOTE: BE SURE THE STOVE IS TURNED OFF, THE POWER CORD IS UNPLUGGED, AND THE UNIT IS COLD BEFORE CLEANING OR SERVICING. RECOMM

CLEANING INSTRUCTIONS…continued WARNING: DISCONNECT THE POWER CORD BEFORE CLEANING OR SERVICING THIS UNIT. THE STOVE MUST BE TURNED OFF AND COOLED

CLEANING INSTRUCTIONS…continued WARNING: DISCONNECT POWER CORD BEFORE CLEANING OR SERVICING. NOTE: CLEANING INTERVALS MAY VARY GREATLY WITH DIFFER

WIRING DIAGRAM WARNING: DISCONNECT POWER CORD BEFORE SERVICING THIS UNIT: OPTIONAL SOLAR PANEL CONNECTIONS WARNIN

SECTION PAGE Introduction……………………………………………………… 1 Automatic Features……………………………………………… 2 Safety Warnings…………………………………………………. 3, 4

REPLACEMENT PARTS LIST ITEM QTY P/N DESCRIPTION ITEM QTY P/N DESCRIPTION 1 1 ES 010 Convection Fan Motor DC 16 1 DV 160 Norprene ¼”

AUTOMATIC FEATURES A. THERMOSTAT OPTION: When using a thermostat, set the stove to one of the medium or higher settings. The stove will burn at

SAFETY WARNINGS If this stove is not properly installed, operated and maintained, a serious house fire may result. Always follow the recommended cle

SAFETY WARNINGS…CONTINUED FIRE EXTINGUISHER: Every home should have at least one fire extinguisher. An approved “class a-b-c” extinguisher should b

INSTALLATION PRECAUTIONS CAUTION: Do not install this appliance in any manner other than as described in this manual. If you have any questions abo

MOBILE HOME REQUIREMENTS SPECIAL MOBILE HOME REQUIREMENTS: WARNING: DO NOT INSTALL IN A SLEEPING ROOM. An outside air source must be connected to

CLEARANCES CONVENTIONAL CLEARANCES A…SIDEWALL 9 In. (229 mm) B…BACK WALL 3 In. (75 mm)……(VERTICAL VENTING INSTALLATION REQUIRES A MIN. 3”

VENT TERMINATION INSTRUCTIONS NOTE: The following are general instructions for installing this appliance. THE VENT PIPE MANUFACTURER’S INSTRUCTI