American-energy-systems MagnuM Baby Countryside User Manual

1Magnum Baby Countryside Corn/ Biomass / Wood Pellet Stove NOTE: THESE INSTRUCTIONS MUST BE SAVED for future reference PLEASE READ THIS ENTIR

10 It is recommended that only an authorized Magnum installer install your pellet/corn stove. The following installation guidelines must be follow

11GUIDELINES FOR EXHAUST VENTING SYSTEMS DESIGN, CONT…… To determine whether a 3” or 4” exhaust system should be used, follow the guidelines below:

12 OUTSIDE MAKE-UP AIR FOR COMBUSTION IS REQUIRED ON ALL INSTALLATIONS 1) For FREESTANDING installations with horizontal through-the-wall exhaust

13 INSTALLATION PRECAUTIONS CAUTION: Do not install this appliance in any manner other than as described in this manual. If you have any questions

14 The Magnum Corn/Biomass Wood Pellet Appliances may be installed as follows: 1) A freestanding unit 2) A built-in heater mounted in an alcove

15VENT TERMINATION GENERAL INSTRUCTIONS NOTE: The following are general instructions for installing this appliance. THE VENT PIPE MANUFACTURER’S I

16HORIZONTAL INSTALLATION EXHAUST VENT TERMINATION SHALL BE AS FOLLOWS: A MINIMUM OF 4 FEET/122Omm BELOW, BESIDE AND 1 FOOT ABOVE ANY DOOR OR WINDO

17 VERTICAL INSTALLATION GUIDELINES ON CONNECTING TO AN EXISTING FACTORY-BUILT CHIMNEY: 1. Inspect the chimney for the presence of creosote, soot

18 Warning: Unless the venting is enclosed and insulated, this installation will cause poor venting, excess ash buildup, premature failure of exha

19AC CONTROL PANEL/THERMOSTAT HOOK-UP WARNING: ALWAYS DISCONNECT POWER CORD DURING ANY ELECTRICAL OPERATION 1. Remove control panel from prot

2Rev. date 03/05 SECTION PAGE Introduction / Specifications..…………………………………… 3 Technical Bulletin/Importance of Adequate Fresh Air………….

20 DC CONTROL PANEL/THERMOSTAT HOOK-UP WARNING: ALWAYS DISCONNECT POWER CORD DURING ANY ELECTRICAL OPERATION 10. Remove control panel from pr

21 OPTIONAL 12 VOLT BATTERY BACK-UP WARNING: ALWAYS DISCONNECT POWER CORD DURING ANY ELECTRICAL OPERATION Note: Never use an unsealed battery 1.

22OPERATING INSTRUCTIONS (DC Models) NOTE: Each time the stove is started, the firepot should be checked for debris and clear air holes. Some fuel

23OPERATING INSTRUCTIONS (AC models) NOTE: Each time the stove is started, the firepot should be checked for debris and clear air holes. Some fuel

24OPERATION INSTRUCTIONS…continued (ALL MODELS) PROPER FUEL This stove is designed and approved to burn approved Biomass fuel only. Do not use any

25CLEANING INSTRUCTIONS NOTE: BE SURE THE STOVE IS TURNED OFF, THE POWER CORD IS UNPLUGGED, AND THE UNIT IS COLD BEFORE CLEANING OR SERVICING. REC

26CLEANING INSTRUCTIONS…continued WARNING: DISCONNECT THE POWER CORD BEFORE CLEANING OR SERVICING THIS UNIT. THE STOVE MUST BE TURNED OFF AND COOL

27 The Convection (room fan) blower will accumulate dust, cat hair, etc. on the blades during the heating season. This must be vacuumed clean as ofte

28C. Inspection and Removal-The chimney connector and the chimney should be inspected to eliminate the risk of a chimney fire. Check the chimney fr

29auger will stop feeding. However, the blowers will continue to run until the POP switch has cooled down to initiate the shut down cycle. Your

3 DEAR VALUED MAGNUM PRODUCT OWNER, We appreciate your decision to help preserve our precious environment by purchasing your Magnum Corn/Biomass Wo

30 Startup/ normal operation When the circuit board is energized (the On/Off button is pushed), the start up cycle is initiated. This starts a t

31 Basic Circuit Board Functions (expanded) / Diagnostics operation

32 A proper draft setting is crucial to the successful burning of solid fuels. Draft refers to the amount of air flowing through the burn chamber

33 AC MODEL WIRING DIAGRAM WARNING: DISCONNECT POWER BEFORE SERVICING THIS UNIT. DC MODEL DDC-3000

34DIAGRAM WARNING: DISCONNECT POWER BEFORE SERVICING THIS UNIT

35OPTIONAL SOLAR PANEL CONNECTIONS WARNING: Use a 3 AMP, 50 volt diode on the “+” positive lead between the solar panel and battery as shown in the d

36IGNITER REPLACEMENT The igniter system on the Magnum appliances’ is an integral part of the wiring system. If the igniter is shorted out, the wiri

37TROUBLE SHOOTING GUIDE Unplug power to the appliance before performing any service. PROBLEM CAUSES SOLUTIONS ? Fire burns with a lazy, orange f

38PROBLEM CAUSES SOLUTIONS ? Fire goes out or stove shuts down automatically. ♦ Hopper is empty. ♦ Fuel is not feeding. ♦ High limit tempera

39PROBLEM CAUSES SOLUTIONS ? Blower will not operate. ♦ No power to stove. ♦ No power to control board. ♦ Blower has overheated d

4 Technical Bulletin Importance of adequate fresh air Every home is a slightly different situation and depending on the design of the air movement

40PROBLEM CAUSES SOLUTIONS Fuel burns off to quickly, have difficulty keeping a pilot fire. Air shutter is open to far. Over drafting on a vertica

41MAGNUM APPLIANCES REPLACEMENT PARTS PRICE LIST ORDER # MODEL NAME/DESCRIPTION CONSUMER PRICING BC-Igniter Magnum Baby Countryside Auto-Light syst

5 YEAR LIMITED WARRANTY This warranty is issued by American Energy Systems, Inc. (Manufacturer) and extends only to the original purchaser of this pr

43SERVICE RECORD DATE SERVICE OR CLEANING PERFORMED

5make sure that there is nothing mechanical wrong with the appliance and then determine your need for proper fresh air. Your dealer can contact the f

IMPORTANT: Proper installation of this stove is crucial for proper and safe operation. Installing this product improperly may result in a house

7 Unlike petroleum and natural gas products, solid fuels such as corn and wood pellets create ash as the fuel is burned. Even with the highly eff

89 There are many varieties of corn grown around the world. Each variety has unique characteristics including the shape and size of the kernel. Yo

9CLEARANCES CONVENTIONAL CLEARANCES A…SIDEWALL 9 In. (229 mm) B…BACK WALL 3 In. (75 mm)……(VERTICAL VENTING INSTALLATION REQUIRES A MIN. 3”